2wd – dirt and diy

Lifting your 80’s Toyota Van

October 26, 2021November 1, 2021 www.constantcompass.comLeave a comment

A question I see that’s common on facebook groups and Toyotavantech website is how do I raise my Toyota Van? There are no lift kits available for any of our vans, that inclues 1984-1989. I’m no expert but what the options I’ve seen are below. Disclaimer: I didn’t do any of the experimentation, I benefited from others experimenting and I used their results on my own van.

ncbrock’s van, photo from ToyotaVanTech, posted on Imgur.

For the front, crank the torsion bars. These torsion bars lift the front of the van. Note, that some say there are some negatives to maxing these out. Putting more stress on the system. This will help you fit larger tires in the front.

For the rear, if you have coils:

You can use a daystar spacer (Daystar Part # KT09100BK). The spacer needs to have about a 1/2″ cut out to make fit over the top of the rear coil springs. Make sure to replace bottom rubber as well if it’s warn out. More detailed info here.
You can change your springs to Moog CC845 made for the Ford Aerostar Van, you will need to cut 1 to 3 coils off. Some report that because of cutting the coils, the springs will start to sag after a while and provide poor performance. This is debated.

For the rear, if you have leaf springs (most cargo vans, although I have a cargo with springs):
1. Add a leaf
2. Add longer shackles.
Find more info on post #9 of this post on ToyotaVanTech.

For both front and rear,

Longer shocks. Detailed here, post number 5. Note that person has a 4wd model. You may need to use different shocks than that person if you have a 2wd. Some use Toyota Tacoma all around. This person used Durango shocks in the front and Tacoma shocks in the back.

With doing these two things alone, you should be able to fit General Grabbers on both 2wd and 4wd without rubbing. On some 2wd models, depending on age of shocks, you may need to do some cutting.

For tires,

Most people’s goal are to fit the General GRABBER A/TX – SIZE: 27X8.5R14LT on their van.

I currently have the LT195/75R14 – STARFIRE SF*510 LT tires on my van. They’ve done alright in a lot of conditions and aren’t noisy. It doesn’t look like they’re made anymore.

Hope that helps consolidate some lifting information for our Toyota Van’s. Please comment if you have any other info or ideas.

van camping in the shasta/trinity marble mountain beauty

September 19, 2020September 19, 2020 www.constantcompass.comLeave a comment

There are some places that are filled with beauty everywhere you look. Despite recent fires in the area, Shasta-Trinity area is one of these places. Alpine lakes, cold streams, single track trails, and secret swimming holes. In July we chose to load up the van and take a 5 day trip to explore the area that for me is filled with familiar and still unfamiliar places. We made our way along dirt and gravel roads in the old Toyota. It held up just fine and it was nice knowing that we can stop anywhere, sleep, make lunch and have everything one would need.

We made our way around up I-5 through Redding and past Whiskeytown Lake which was burned recently. I’ve never stopped at this lake before but it’s nice view driving by. I believe I’ve seen some sailboats in this lake too which would be a lot of fun. Sometime after Whiskeytown Lake you take a right and meander over and around Trinity Lake and the KOA campground. Somewhere after the KOA campground, we took a left and drove down a paved road that eventually turned to gravel and has many trailheads for overnight backpacking trips. You’ll pass waterfalls even in the middle of summer. It was late at night and the new LED headlights lit up the road well. I knew where the waterfall is alongside the road and made a special stop. We could hear the sound of the waterfall and with a quick flip of the switch, the side spotlight lit up this beautiful waterfall. The best use of the side spotlight so far. We eventually made it into camp and were grateful that it wasn’t occupied.

An advantage of the van is that no bed needs to be made. We popped open the back of the van, made some tea, danced and watched the stars late into the night. We then decided it was time to go to bed but not before admiring the Milky Way and watching the bats dance above our heads. There’s nothing like falling asleep to the sound of a rushing creek except for the sound of waking up to rushing creek.

Along a dirt road in Shasta-Trinity National Forest area.

I set up my tenkara rod and tossed a few dry flies into the nearby creek, pulling out a couple small rainbows before deciding to take a cold dip. We stripped our clothes and took a dip into the icy cold water. We made breakfast, then made our way to a close trailhead where we packed our bags for a short hike. Not but one mile in we came across the small bear who also thought it was good idea to be on the trail today. What a magical animal to come across. Humans (including me at times) tend to walk around with fear of certain animals like sharks and bears but often they want nothing to do with us. This bear was no exception when it quickly ran off. We bathed again along the creek and green vegetation before heading back to the van.

The next day we head North through the town of Etna for a hike at Taylor Lake. We didn’t drive through Etna without stopping as the heat required an ice cream stop at the local cafe. We got back on the road and got to the trailhead where we met with a fire crew that just got done fighting a lighting fire. There was some smoke in the air but if you live on the West Coast, it was nothing like what we’ve faced in recent weeks. A friendly crew that was quite lively, dirty, and grateful for the ability to work outside. We thanked them for the work they do before we answered a few questions about the van and headed towards Taylor Lake. Smith Lake requires you to reach hike to Taylor Lake (1 mile) then head straight up a slope which is quite intense, especially in the sun. We made it to the top where it meets the PCT and tried to find a route down to Smith Lake but it was pretty gnarly so we decided to head back to Taylor Lake. If we spent more time route finding we could have made our way down but at that point we were low on water and wanted to take a swim which Taylor Lake was the perfect place for that. Taylor Lake is pretty popular so heading down to Smith Lake will get you away from the crowds.

A beautiful garden in the cute town of Etna.

At this point, it was time to find a place to sleep for the night and get prepared for our next hike which was going to be to Statue Lake. Halfway up the road to Statue Lake, we found a spot to pull over next to a creek and it was nice place to lay our heads, do some bird watching and cook dinner.

A rock where we enjoyed a morning meditation together.

The next day we woke up slowly, watched the birds, deer came to visit and they were curious about what we were doing. We made our way to the trailhead and began our hike. A lot of the area up to the top is burned but there were some nice wildflowers blooming along the trail. Statue Lake had visitors when we arrived but we were glad we made the stop. Jumping off the rock on the far side of the Lake, laying in the sun and enjoying being far away from cell service.

A beautiful woman and a beautiful lake (Statue Lake).

The last night was spent along the N. Fork of Salmon Creek where we found a spot all to ourselves. The fishing wasn’t great but the creek was ride and Mallory found a spot to take a cold plunge. We danced until the stars came out and the full moon showed itself. We were feeling the fullness of the moon and the trip as we counted down our last hours.

dry car camping along highway ca-89

September 16, 2020September 19, 2020 www.constantcompass.comLeave a comment

(This trip occurred in Spring 2019)

One way to get to the East Sierras from the Bay Area is through Highway 89. Most people’s destination lie past this highway and along highway 395 somewhere but I argue to take a stop along this highway to enjoy the beauty this area has to offer. CA-89 goes through a goo size portion of California and for this post I’ll be talking about the part of the highway south of highway 50. Along this section of the highway you’ll make your way along the West Fork of the Carson River which I’ve never fished but have heard of good fly fishing and often see many lining this section of River.

Where 89 meets CA-88, if you turn right and head East on 88, you’ll see pull outs for a couple miles that offer access to fishing the West Fork of Carson River. This adventure had us turning left and continuing on 89 through the cute town of Markleeville. Right after the turn about a 1/4 mile up and on your right is a bakery/cafe worth stopping at (Hope Valley Cafe).

West Fork Carson River past the Hope Valley Cafe.

As you travel further down the road, you’ll drive right through the town of Markleeville. Markleeville is a quaint town and is the start of the Death Ride, a bicycle ride that transverses the passes. Those who finish this ride will have travelled 125 miles and climbed 25,000 feet in elevation. I’ll save my legs this time around but I do plan to do this ride some day! You can stop in town at the deli cafe for a breakfast burrito or sandwich or take a peak inside the information center to learn more about the town. There’s also a small post office and general store. The river follows the highway until 89 turns off and heads East. Along this stretch of the highway, it’s worth stopping for a break and a nice walk around Heenan Lake. Heenan Lake is full of heritage trout, if you wait long enough around the shores of this lake, you’ll see schools of very large trout, quite the scene. If you happen to visit in spring, you’ll also be given a nice wildflower show that coats the hillside.

A view from the hillside at Heenan Lake (June).

Between Heenan Lake and 395 is where we pulled off and tested the off road capabilities of my 85 Toyota Van. We were lucky to find a spot that was private, although not close to water, it was located around some beautiful woods with great bird watching and day hikes. It’s amazing what you see when you pull off the highway, park your car and take hikes over tops of mountains. Valleys filled with quiet except for the birds that scatter amongst the brush and blooming scrub.

A view we were treated with on a day hike from camp.

The colors of wildflowers were beautiful. The camera never captures the full beauty.

We spent a beautiful 3 days here, waking up, watching birds, playing the banjo, and taking day hikes to see what others can’t see while driving on the highway. We ate simply and enjoyed the slowness of it all. Cool mornings, morning coffee and allowing ourselves to sit in one spot til the birds became comfortable with our presence is something that was so refreshing and energizing. It was lovely time of relaxation and I’d do it again in a heartbeat.

upgrades to the toyota camper van conversion (vol. 2)

March 28, 2020September 19, 2020 www.constantcompass.com3 Comments

It was a busy winter filled with camping and fishing, just the way I like it. While going on these adventures I was able to continually add to a list of modifications I would like to perform on the van. There’s so much joy in using something and making tweaks to better suit your needs. The only constant is change, it’s cliche but it’s true. Let me not get stuck on how the way things are now but what they can become. Below is an incomplete list of modifications I’ve done on the van since the last update.

Went here:

Processed with VSCO with 4 preset — random free camping in the forest.

Got rained on. My ARB awning was stolen so my solution was to grab what wood
I had and attach it the racks. It protects the inside of the van from light showers. If it’s heavy sideways rain, it’s not going to work as well. Total cost $0

Since you’ve been following so close attention, you may have noticed the new cargo rack on the top. It’s the one offered at harbor freight. I think it’s around 50 bucks. It’s pretty useful although it does make this van that much of a kite in the wind. I took off sticker and painted the wind deflector all black.

Oh, well, will you look at that. I just gave away another modification. LED lights in the front now. No longer does it feel like an oil lantern in front of my van. I can now equally blind the other drivers who happen to enter my path. Jokes aside, the wires needed modification and my mechanic removed some of the working LEDs when the lights are in low. He said you would likely get pulled over if you kept all of the LEDs working on lo beam.

Added this sick sticker, added at least 10HP. Contact Aaron Morrell.

Got this console from my mechanic for free. Came through in the clutch, thanks Gustavo!

Back up light installed. I drilled a hole in the side of the solar panel rail and ran the wires to a switch under the hatch. Below is a video of the light in action.

switch for reverse light. will consider moving this switch up to the dash.

Side light for the porch. Bought these lights off amazon for less than 20. They’re pretty bright and contain six LEDs.

pretty useful to have a table inside.

how i mounted it.

new book i bought to learn more about salmon and trout.

My Lagun table mount, those things cost a fortune but I’ve seen some blemished ones on eBay at a discount. The table top I made out of sanded 3/4″ plywood. Came out real nice with two coats of stain and two sprays of marine varnish.

I covered the folding table in the back of the van with plexiglass that was leftover from a project. This table typically gets covered when cooking multiple meals. The plexiglass make it really easy to wipe. Be careful when installing the plexiglass, it cracks easily. I used screws to hold it in. I drilled pilot holes and went until firm but not overly tight.

I held off because I didn’t want anything on the vinyl or the window but I finally added a phone holder. Cheap one off eBay for six bucks. It holds well, I just hope it doesn’t ruin the vinyl.

usb outlets installed on my 1985 toyota van.

USB ports installed behind the couch. If running usb ports from 12v, you need to have a converter that converts the power to 5v.

Painted the step and installed the metal frame.

LED light bar in the back of the van under the shelf.

I removed the old bright white light and replaced it with two warm white led bars. Having one below the shelf and above really helps when cooking. A lot of the light was blocked with only one light on the roof.

TO BE CONTINUED…

I want to write a short post about my new layout for sleeping and lounging.